小儿硫酸亚铁糖浆

小儿硫酸亚铁糖浆 深圳市职业技能鉴定药物制剂工,中级，实操考试(二) 本套试题准备页 一、考试现场要求: 符合GMP要求的液体制剂生产场所，本次操作要求在相应的D级洁净环境 中进行，并有温度、湿度、时间的显示装置。 二、操作设备及容器要求: 电子天平(或托盘天平)5台 量筒10ml、50ml、100ml各10个 烧杯50ml、100ml、250ml各10个 电炉 5台 玻璃棒 10根、 玻璃漏斗 10个 液体制剂灌装机1台 50ml玻璃瓶、瓶盖、胶塞各100个 精制棉 1筒 三、按每人下列数量准备物料: 硫酸亚铁 4g 枸橼酸 0.21g 蔗糖 85g 纯化水 500ml 四、所用仪器、设备的操作SOP Otherwise the pump should be checked again to install. 4.2.5.1 structure embedded phase 1, toilet drain structure places a waterproof steel bushings, measure width of the beam, use galvanized steel pipe welding and sealing rings, measure elevation on positions in the structure main bars of beams, welded prison using sawdust block. Hole thin iron sleeve construction, length about 200 mm, easy installation and handle construction, casing used touch Remover (available used oil paint), Eachd8, transfer and underground drainage pipe installation mounting, hang-dry pipe must first make an outline, the carrier according to the design of slope planted well hung code, pipe hangers, prefabricated piping Bay and state provision and other sanitary and drainage provision for finding sizes, clamp the connection interface. The connection between the pipe and the main pipe to ensure smooth, sloping according to design requirements, no camber behavior occurs. Buried trunk pipe supporting frame, before you install DUN, planted well pipe sizes, will be reserved for finding and fixed the pipe size, and then sealing with cement mortar. 9, after the construction of water testing, water testing and well outside through-ball after completion of construction. 10, construction notes: when using metal pipe clamps, 深圳市职业技能鉴定药物制剂工,中级，实操试卷(二) 姓名: 准考证号: 项目一:小儿硫酸亚铁糖浆制备操作 (60分) 规格:每ml含硫酸亚铁40mg,枸橼酸2.1mg 处方: 硫酸亚铁 4g 枸橼酸 0. 21g 纯化水 15ml 单糖浆加至100ml 1、操作前进行检查(5分) 2、按所给处方进行称量(15分) 、按给定的操作提示，配制合格的药液(20分) 3 4、将所配制的药液按给定的操作提示用液体制剂灌装机装入玻璃瓶(10ml/瓶)10ml并轧盖(10分) 5、将操作过程记录在生产记录中(5分) 6、操作完毕后，对操作现场进行清理，将所用设备按GMP要求清洁干净，按要求填写清场记录(5分)。 项目二 常用溶液的配制(20分) 1、75%乙醇溶液的配制 2、0.25%的新洁尔灭溶液的配制 项目三 消防安全(20分) 1、演示说明灭火器的使用 2、回答问题:发生火灾事故怎么办, Otherwise the pump should be checked again to install. 4.2.5.1 structure embedded phase 1, toilet drain structure places a waterproof steel bushings, measure width of the beam, use galvanized steel pipe welding and sealing rings, measure elevation on positions in the structure main bars of beams, welded prison using sawdust block. Hole thin iron sleeve construction, length about 200 mm, easy installation and handle construction, casing used touch Remover (available used oil paint), Eachd8, transfer and underground drainage pipe installation mounting, hang-dry pipe must first make an outline, the carrier according to the design of slope planted well hung code, pipe hangers, prefabricated piping Bay and state provision and other sanitary and drainage provision for finding sizes, clamp the connection interface. The connection between the pipe and the main pipe to ensure smooth, sloping according to design requirements, no camber behavior occurs. Buried trunk pipe supporting frame, before you install DUN, planted well pipe sizes, will be reserved for finding and fixed the pipe size, and then sealing with cement mortar. 9, after the construction of water testing, water testing and well outside through-ball after completion of construction. 10, construction notes: when using metal pipe clamps, 项目一:小儿硫酸亚铁糖浆制备操作 药物制剂工技能鉴定操作记录(考生填写) 品名 规格 批号 操作日期 年 月 日 房间编号 温度 ? 相对湿度 % 操作步骤 操作要求 操作记录 操作时间 1、 设备是否完好正常 ?是 ?否 时 分~ 操作前检设备、容器、工具是否清洁 ?是 ?否 时 分 查 计量器具仪是否校验合格 ?是 ?否 2、 称量:(实际操作情况由考生写在下面) 1、 按生产处方规定，称取(量取)经处理称量 硫酸亚铁 4g 好的物料，记录品名、用量。 枸橼酸 0.21g 时 分~ 2、 在称量过程中执行考生称量，监考人员 蔗糖 85g 时 分 纯化水 ml 复核。 3、 配制:(实际操作情况由考生写在下面) 操作提示: 配制 1、制备单糖浆 2、物料溶解 时 分~ 3、过滤 时 分 4、配制 Otherwise the pump should be checked again to install. 4.2.5.1 structure embedded phase 1, toilet drain structure places a waterproof steel bushings, measure width of the beam, use galvanized steel pipe welding and sealing rings, measure elevation on positions in the structure main bars of beams, welded prison using sawdust block. Hole thin iron sleeve construction, length about 200 mm, easy installation and handle construction, casing used touch Remover (available used oil paint), Eachd8, transfer and underground drainage pipe installation mounting, hang-dry pipe must first make an outline, the carrier according to the design of slope planted well hung code, pipe hangers, prefabricated piping Bay and state provision and other sanitary and drainage provision for finding sizes, clamp the connection interface. The connection between the pipe and the main pipe to ensure smooth, sloping according to design requirements, no camber behavior occurs. Buried trunk pipe supporting frame, before you install DUN, planted well pipe sizes, will be reserved for finding and fixed the pipe size, and then sealing with cement mortar. 9, after the construction of water testing, water testing and well outside through-ball after completion of construction. 10, construction notes: when using metal pipe clamps, 操作提示: 4、 灌装与轧盖:(实际操作情况由考生写在下面) 1、开机前检查 灌封 2、试运行 3、调节装量。 4、运行 时 分~ 5、操作结束 时 分 备注 操作人 复核人 药物制剂工技能鉴定清场记录(考生填写) 品名 规格 批号 日期 年 月 日 班 清场项目及要求 1、生产结束后将物料全部清理,并定置放置。 2、撤除本批生产状态标志。 清3、使用过的设备容器及工具应清洁无异物并实行定置管理。 场 要4、设备内外尤其是接触药品的部位要清洁，做到无油污，无异物。 求 5、地面，墙壁应清洁，门窗及附属设备无积灰，无异物。 6、不留本批产品的生产记录及本批生产指令书面文件。 设 项 目 清场者检查情况 复核者检查情况 备 称量工具 清 洁 生产设备 及 生产状态标志撤除 物 料 记录台文件清理 清 地面、墙壁、天花板、玻璃应清洁 理 使用过的容器及工具清洁 清场结论: 1、 检查合格者打“?”;不合格者打“×”。 备注 清场者 复核者 项目二 常用溶液的配制(20分) Otherwise the pump should be checked again to install. 4.2.5.1 structure embedded phase 1, toilet drain structure places a waterproof steel bushings, measure width of the beam, use galvanized steel pipe welding and sealing rings, measure elevation on positions in the structure main bars of beams, welded prison using sawdust block. Hole thin iron sleeve construction, length about 200 mm, easy installation and handle construction, casing used touch Remover (available used oil paint), Eachd8, transfer and underground drainage pipe installation mounting, hang-dry pipe must first make an outline, the carrier according to the design of slope planted well hung code, pipe hangers, prefabricated piping Bay and state provision and other sanitary and drainage provision for finding sizes, clamp the connection interface. The connection between the pipe and the main pipe to ensure smooth, sloping according to design requirements, no camber behavior occurs. Buried trunk pipe supporting frame, before you install DUN, planted well pipe sizes, will be reserved for finding and fixed the pipe size, and then sealing with cement mortar. 9, after the construction of water testing, water testing and well outside through-ball after completion of construction. 10, construction notes: when using metal pipe clamps, 项目 操作要求 操作记录 操作时间 1、75%乙醇溶1、计算: 取95%乙醇 ml加纯化水至 液的配制 时 分~ 100ml，即得。 2、配制: 时 分 2、0.25%的新1、计算: 取5%的新洁尔灭 ml加纯 洁尔灭溶液 时 分~ 化水至100ml，即得。 的配制 2、配制: 时 分 操作人 复核人 项目三 消防安全(20分) 1、演示说明灭火器的使用 2、回答问题:发生火灾事故怎么办, 深圳市职业技能鉴定药物制剂工,中级，实操考试(二) 评分标准 项目一 小儿硫酸亚铁糖浆制备操作 满分:60 得分:_________ ________年________月________日 考核时间定额在: 210 分钟 考生姓名: 准考证号: 监考人: 评卷人: 考试 扣分记录及备技术要求与评分标准 配分 得分 内容 注 1、 1、有检查动作 2 操作前5 3 2、检查得出正确结论 检查 2、 1、根据称量物品的重量(体积)正确选用用天平、量筒。 5 称量 没有根据称量物品的重量(体积)正确选用用天平、量筒扣5 分。 2、正确使用天平、量筒。 5 15 使用天平、量筒每出现一处失误扣2分，扣完为止。 3、称量的结果正确 5 每种物料要求在称量的结果合格的误差范围内，错误一项扣1 分，扣完为止。 Otherwise the pump should be checked again to install. 4.2.5.1 structure embedded phase 1, toilet drain structure places a waterproof steel bushings, measure width of the beam, use galvanized steel pipe welding and sealing rings, measure elevation on positions in the structure main bars of beams, welded prison using sawdust block. Hole thin iron sleeve construction, length about 200 mm, easy installation and handle construction, casing used touch Remover (available used oil paint), Eachd8, transfer and underground drainage pipe installation mounting, hang-dry pipe must first make an outline, the carrier according to the design of slope planted well hung code, pipe hangers, prefabricated piping Bay and state provision and other sanitary and drainage provision for finding sizes, clamp the connection interface. The connection between the pipe and the main pipe to ensure smooth, sloping according to design requirements, no camber behavior occurs. Buried trunk pipe supporting frame, before you install DUN, planted well pipe sizes, will be reserved for finding and fixed the pipe size, and then sealing with cement mortar. 9, after the construction of water testing, water testing and well outside through-ball after completion of construction. 10, construction notes: when using metal pipe clamps, 10 3、配制 1、确定正确的操作步骤如下，并规范操作 (1)单糖浆的制备:取纯化水45ml，煮沸，加蔗糖，不断搅拌 溶解后，继续加热至100?使溶液澄清，趁热用精制棉过滤， 自滤器上加适量热纯化水，使成100 ml,搅匀，即得。 20 (2)取枸橼酸溶于全量纯化水中，加入预先研细的硫酸亚铁，搅 拌使溶解 (3)将上述溶液进行过滤，滤液与适量单糖浆混匀，边加边搅 拌，再加单糖浆至50 ml，搅匀。 10 2、制备出合格的口服溶液。 5 4、 1、确定正确的操作步骤如下，并规范操作 灌封 (1)开机前检查 (2)开启电源试运行 10 (3)开动机器调节装量。4、运行罐装 (4)工作完毕，关闭电源，清洁机器 (5)灌装轧盖 5 2、灌装装后的药品封口良好，装量准确确，密封完整。 5、生产1、内容真实，记录及时。2、字迹清晰 记录填3、不得任意撕毁或涂改4、按表格内容填写齐全，数据完整5、5 写 品名等应写全名6、签名时应签全 以上6项每出现1项错误扣2分，扣完为止。 6、清场1、 清场要求见清场记录。 及清场2、清场记录填写要求同生产记录的填写要求。 3、规范完成清场过程8分 记录填5 4、清场记录填写2分， 写 对不符合要求的，每一空格扣一分，扣完为止 5、具体填写内容见所附清场记录 项目二 常用溶液的配制 满分:20 得分:_________ ________年________月________日 考核时间定额在: 30 分钟 考生姓名: 准考证号: 监考人: 评卷人: 考试内容 技术要求与评分标准 配分 扣分记录及备注 得分 4 1、75%乙醇溶液的配制 1、在空格处填上正确的取用数79 ml， 2 并写出计算过程 10 4 2、使用正确的容器 3、配制结果正确 4 2、0.25%的新洁尔灭1、在空格处填上正确的取用数5 ml， 2 溶液的配制 并写出计算过程 10 4 2、使用正确的容器 3、配制结果正确 Otherwise the pump should be checked again to install. 4.2.5.1 structure embedded phase 1, toilet drain structure places a waterproof steel bushings, measure width of the beam, use galvanized steel pipe welding and sealing rings, measure elevation on positions in the structure main bars of beams, welded prison using sawdust block. Hole thin iron sleeve construction, length about 200 mm, easy installation and handle construction, casing used touch Remover (available used oil paint), Eachd8, transfer and underground drainage pipe installation mounting, hang-dry pipe must first make an outline, the carrier according to the design of slope planted well hung code, pipe hangers, prefabricated piping Bay and state provision and other sanitary and drainage provision for finding sizes, clamp the connection interface. The connection between the pipe and the main pipe to ensure smooth, sloping according to design requirements, no camber behavior occurs. Buried trunk pipe supporting frame, before you install DUN, planted well pipe sizes, will be reserved for finding and fixed the pipe size, and then sealing with cement mortar. 9, after the construction of water testing, water testing and well outside through-ball after completion of construction. 10, construction notes: when using metal pipe clamps, 项目三 消防安全 满分:20 得分:_________ ________年________月________日 考核时间定额在: 20 分钟 考生姓名: 准考证号: 监考人: 评卷人: 考试内容 扣分记录及备注 得分 技术要求与评分标准 配分 1、演示说明灭火器的使用 5 1、正确理解灭火器的使用说明 5 10 2、正确演示灭火器的使用操作 2、回答问题:发生火灾事2 1、要迅速向消防队火警。 2 2、在能扑救的情况下迅速组织扑救。 故怎么办, 3、在可疏散贵重物品的情况下迅速2 疏散物品。 4、在不能扑救的情况下迅速组织人2 员疏散。 10 5、主动为消防队扑救火灾提供情况1 和方便条件。 6、火灾扑灭后不应随便清理现场,在 1 公安消防机构调查火灾原因时,如实 提供有关情况。 Otherwise the pump should be checked again to install. 4.2.5.1 structure embedded phase 1, toilet drain structure places a waterproof steel bushings, measure width of the beam, use galvanized steel pipe welding and sealing rings, measure elevation on positions in the structure main bars of beams, welded prison using sawdust block. Hole thin iron sleeve construction, length about 200 mm, easy installation and handle construction, casing used touch Remover (available used oil paint), Eachd8, transfer and underground drainage pipe installation mounting, hang-dry pipe must first make an outline, the carrier according to the design of slope planted well hung code, pipe hangers, prefabricated piping Bay and state provision and other sanitary and drainage provision for finding sizes, clamp the connection interface. The connection between the pipe and the main pipe to ensure smooth, sloping according to design requirements, no camber behavior occurs. Buried trunk pipe supporting frame, before you install DUN, planted well pipe sizes, will be reserved for finding and fixed the pipe size, and then sealing with cement mortar. 9, after the construction of water testing, water testing and well outside through-ball after completion of construction. 10, construction notes: when using metal pipe clamps,